Recent Content by WMurphy

I have a 2003 Dodge 2500 with automatic transmission, occasionally there will be a delayed shift waiting until 2500-2600 RPM to shift under partial throttle / fuel pedal. If I cycle the fuel pedal thru full travel (push fuel pedal to floor momentarily), then the normal shift points are restored...

I had a similar problem with my FASS DDRP lift pump, it died (2500 miles, 8 months old), sent it back to FASS, they retorqued the case bolts to fix the problem. A bunch of them left the factory with case bolts improperly torqued!!! I went back to original equipment Carter lift pump and have...

I had the trans in drive, not overdrive This is a one time occurrence, it won't happen again.

I severely overload my truck by pulling a trailer weight 15,500lbs thru mountainous territory. The 2000 quad cab 2500 truck was pulling a steep grade, the last mile the engine temp gage went to 240F (gage pegged?) and the trans temp went to 220F. The radiator did NOT boil over, the trans...

In Tank Lift Pump Thanks for the informative replies!!! TDR forums are great!!

The transfer pump is located in fuel tank? Is this an aftermarket mod or OEM upgrade. The transfer pump relay is mounted on firewall and a "fuel block" is located where I would expect to find transfer pump on left side of block. I am questioning source, for future repairs Thanks for any help

OEM Pump replaced FASS Pump I found the OEM Cummins transfer pump was more reliable than FASS DDRP pump. To correct problem, I replaced FASS pump with an OEM pump

Thanks for your response!! I finally removed the DDRP pump and hooked it directly to a 12. 4VDC battery. The pump ran, but no pressure, it would no even suck fuel of of a full 5 gallon container! The inlet screen was clean.

FASS DDRP Failed The FASS DDRP transfer pump less than 1 year old, less than 15k miles failed. Zero pressure, required inlet screen is clean I should have left the original pump on the truck If it ain't broke, don't fix it... ... ... ...

I just changed the fuel filter on my 1999 24V Cummins I got in truck to prime, the 1st key switch for momentary crank I got 15psi on my transfer pump pressure gauge. I realized I left water sensor unhooked on filter, reconnected Now zero pressure at filter when I momentary crank I have done...

A/C Clutch Check your A/C compressor clutch to see if it is cracked and loose. The clutch can be changed without removing compressor from engine

I checked the numerous threads on this great site! I ordered a DTT noise filter and will clean ground connections. Any other suggestions? Thanks Wayne

I had same problem, I cleaned APPS electrical connection and problem went away

2000 Gen 2 Diesel, 4 Speed Auto Trans 46RE Between 30 and 50 MPH at cruise, the engine speed will momentarily increase 50 RPM... it may do it once, or repeat 3 or 4 times during slight throttle position (cruise) I turned off overdrive (4th gear) and still had problem. Using odometer and key...